Product Specifications; Replacement Parts; Maintenance Items - Briggs & Stratton 040248 Manuel D'utilisation

Product Specifications

Rated Maximum Power (LP*) . . . . . . . . . . . . . . . . .7.0 kW
Rated Maximum Load Current:
at 240 Volts . . . . . . . . . . . . . . . . . . . . . . . . . . .29.1 Amps
at 120 Volts . . . . . . . . . . . . . . . . . . . . . . . . . . .58.2 Amps
Rated AC Voltage . . . . . . . . . . . . . . . . . . . . .120/240 Volts
Rated Frequency . . . . . . . . . . . . . . . . . .60 Hz at 3600 rpm
Phase . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Single Phase
Power Factor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1.0
LP Fuel Supply Pressure . . . . . . . . . . . . . . . .11-14 in W.C.
NG Fuel Supply Pressure . . . . . . . . . . . . . . . . .5-7 in W.C.
Normal Operating Range -20°F (-28.8°C) to 104°F (40°C)
Output Sound Level . .81 dB(A) at 23 ft. (7 m) at full load
Shipping Weight . . . . . . . . . . . . . . . . . . . . . . . . . . . .280 lbs.
* Natural gas rating will depend on specific fuel but typical derating of generator is between
10 to 20% off the LP gas rating. The power ratings for an individual engine model are initially
developed by starting with SAE (Society of Automotive Engineers) code J1940 (Small Engine
Power & Torque Rating Procedure) (Revision 2002-05). Given both the wide array of products
on which our engines are placed, and the variety of environmental issues applicable to
operating the equipment, it may be that the engine you have purchased will not develop the
rated horsepower when used in a piece of power equipment (actual "on-site" power). This
difference is due to a variety of factors including, but not limited to, the following: differences
in altitude, temperature, barometric pressure, humidity, fuel, engine lubrication, maximum
governed engine speed, individual engine to engine variability, design of the particular piece of
power equipment, the manner in which the engine is operated, engine run-in to reduce friction
and clean out of combustion chambers, adjustments to the valves and carburetor, and other
factors. The power ratings may also be adjusted based on comparisons to other similar engines
utilized in similar applications, and will therefore not necessarily match the values derived using
the foregoing codes.
Engine
Bore . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3.56 in. (90.6mm)
Stroke . . . . . . . . . . . . . . . . . . . . . . . . . . .3.06 in. (77.78mm)
Displacement . . . . . . . . . . . . . . . . . . . . . .30.59 in. (501 cc)
Spark Plug
Type: . . . . . . . . . . . . . .Champion RC12YC or Equivalent
Set Gap To: . . . . . . . . . . . . . . . . . . . .0.030inch (0.76mm)
Armature Air Gap: . . . . . . .0.010-0.014 in. (0.25-0.36mm)
Valve clearance with valve springs installed and piston 1/4 in. (6 mm)
past top dead center of compression stroke (check when engine is
cold).
Intake . . . . . . . . . . . . . . . . .0.003-0.005 in. (0.08-0.13 mm)
Exhaust . . . . . . . . . . . . . . . .0.005-0.007 in. (0.13-0.18 mm)
Oil Capacity (w/o filter) . . . . . . . . . .48 Ounces (1.4 Liters)
Oil Type: . . . . . . . . . . . . . . . . . . . . . .Synthetic SAE 5W-30
NOTE: For practical operation, the generator load should
not exceed 85% of rated wattage. Engine power will
decrease 3-1/2% for each 1,000 feet (300 meters) above
sea level and 1% for each 10° F (5.6° C) above 77° F
(25° C). Engine will operate satisfactorily at an angle up to
15°.

Replacement Parts

Replacement parts are available from your authorized
Briggs & Stratton Service dealer. Each one carries a stock
of genuine Briggs & Stratton service parts and is equipped
with special service tools. Trained mechanics assure
expert repair service on all Briggs & Stratton products.
Only dealers advertising as "Authorized Briggs & Stratton"
are required to meet Briggs & Stratton standards.
When you purchase equipment powered by a Briggs &
Stratton engine, you are assured of highly skilled, reliable
service at more than 30,000 Authorized Service Dealers
worldwide, including more than 6,000 Master Service
technicians.
You may locate your nearest authorized Briggs & Stratton
Service Dealer in our dealer locator map on our web site
www.briggsandstratton.com or in the telephone directory
under "Engines" or "Generators" or similar category.

Maintenance Items

Many convenient and helpful service and maintenance
items are available from your authorized dealer. Some of
these items include:
Air cleaner cartridge
Engine oil
Maintenance kit
Oil filter
Pre-cleaner element
Resistor spark plug
Spark plug wrench
Spark tester
Touch-up paint
23