Greenlee Super Tugger 6000 Serie Manuel D'instructions page 4

IMPORTANT SAFETY INFORMATION
Inspect all components of the cable
pulling system. Verify the maximum
load-bearing capacity or maximum
strength of all structural supports,
pulling system components and
anchoring systems before setting
up the puller. Any component that
cannot withstand the maximum cable
pulling forces may break and strike
nearby personnel with great force.
Failure to observe this warning could
result in severe injury or death.
Do not allow anything other than the
pulling rope to contact the capstan.
A grip, swivel, or other component
could break and strike nearby per-
sonnel with great force.
Failure to observe this warning could
result in severe injury or death.
Do not stand directly under a vertical
pull. Cable could fall suddenly
from the conduit, injuring nearby
personnel.
Failure to observe this warning could
result in severe injury or death.
Do not operate puller if the anti-reverse mechanism
is not working. If you do not hear the clicking of the
anti-reversing pawl when the capstan is rotating, shut
the puller off and have it repaired by an authorized
Greenlee service center.
Failure to observe this warning could result in severe
injury or death.
Greenlee Tools, Inc.
6000-Series Super Tugger
Locate the puller so that it is close to the conduit.
Rope, cable, or connectors can break under tension,
causing the rope to whip violently.
Failure to observe this warning can result in severe
injury or death.
An under-rated rope may break and whip violently.
Use a double-braided composite rope with the follow-
ing characteristics:
• Maximum Rated Capacity:
at least 28.9 kN (6500 lb)
• Average Breaking Strength:
at least 115.6 kN (26,000 lb)
Failure to observe this warning could result in severe
injury or death.
• Check the condition of the entire rope before use.
A worn or damaged rope can break under tension
and whip violently.
• Do not maintain a stationary rope on a rotating
capstan. The wear generated may cause the rope
to break under tension and whip violently.
Failure to observe these warnings could result in
severe injury or death.
4
4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070
Cable Pullers
®