Briggs & Stratton Vanguard 10V000 Manuel D'utilisation page 13

Troubleshooting
For assistance, contact your local dealer or go to VanguardPower.com or call
1-800-999-9333 (in USA).
Specifications
Model: 10V000
Displacement
Bore
Stroke
Oil Capacity
6:1 Gear Reduction - Oil Type (Figure 21)
6:1 Gear Reduction - Oil Capacity (Figure 21)
2:1 Wet Clutch Reduction - Oil Type (Figure 23)
2:1 Wet Clutch Reduction - Oil Capacity (Figure 23)
Spark Plug Gap
Spark Plug Torque
Armature Air Gap
Intake Valve Clearance
Exhaust Valve Clearance
Model: 12V000
Displacement
Bore
Stroke
Oil Capacity
6:1 Gear Reduction - Oil Type (Figure 21)
6:1 Gear Reduction - Oil Capacity (Figure 21)
2:1 Wet Clutch Reduction - Oil Type (Figure 23)
2:1 Wet Clutch Reduction - Oil Capacity (Figure 23)
Spark Plug Gap
Spark Plug Torque
Armature Air Gap
Intake Valve Clearance
Exhaust Valve Clearance
Engine power will decrease 3.5% for each 1,000 feet (300 meters) above sea level and
1% for each 10° F (5.6° C) above 77° F (25° C). The engine will operate satisfactorily
at an angle up to 30°. Refer to the equipment operator's manual for safe allowable
operating limits on slopes.
Service Parts - Model: 10V000, 12V000
Service Part
Paper Air Filter, Model 10V000 (Figure 24)
Paper Air Filter, Model 12V000 (Figure 24)
Paper Air Filter, Low-Profile, Model 10V000 (Figure 25)
Paper Air Filter, Low-Profile, Model 12V000 (Figure 25)
Resistor Spark Plug
Spark Plug Wrench
Spark Tester
We recommend that you see any Briggs & Stratton Authorized Dealer for all
maintenance and service of the engine and engine parts.
Power Ratings: The gross power rating for individual gasoline engine models is
labeled in accordance with SAE (Society of Automotive Engineers) code J1940 Small
Engine Power & Torque Rating Procedure, and is rated in accordance with SAE J1995.
Torque values are derived at 2600 RPM for those engines with "rpm" called out on the
label and 3060 RPM for all others; horsepower values are derived at 3600 RPM. The
gross power curves can be viewed at www.BRIGGSandSTRATTON.COM. Net power
values are taken with exhaust and air cleaner installed whereas gross power values
are collected without these attachments. Actual gross engine power will be higher than
net engine power and is affected by, among other things, ambient operating conditions
and engine-to-engine variability. Given the wide array of products on which engines
are placed, the gasoline engine may not develop the rated gross power when used in a
given piece of power equipment. This difference is due to a variety of factors including,
but not limited to, the variety of engine components (air cleaner, exhaust, charging,
cooling, carburetor, fuel pump, etc.), application limitations, ambient operating conditions
(temperature, humidity, altitude), and engine-to-engine variability. Due to manufacturing
and capacity limitations, Briggs & Stratton may substitute an engine of higher rated
power for this engine.
Warranty
10.313 ci (169 cc)
Briggs & Stratton Engine Warranty
2.44 in (62 mm)
Effective January 2019
2.204 in (56 mm)
Limited Warranty
18 - 20 oz (,54 - ,59 L)
Briggs & Stratton warrants that, during the warranty period specified below, it will repair
80W-90
or replace, free of charge, any part that is defective in material or workmanship or
4 oz (,12 L)
both. Transportation charges on product submitted for repair or replacement under this
warranty must be borne by purchaser. This warranty is effective for and is subject to
10W30
the time periods and conditions stated below. For warranty service, find the nearest
10 oz (,30 L)
Authorized Service Dealer in our dealer locator map at BRIGGSandSTRATTON.COM.
The purchaser must contact the Authorized Service Dealer, and then make the product
.030 in (,76 mm)
available to the Authorized Service Dealer for inspection and testing.
180 lb-in (20 Nm)
There is no other express warranty. Implied warranties, including those of
.010 - .013 in (,25 - ,35 mm)
merchantability and fitness for a particular purpose, are limited to the warranty
period listed below, or to the extent permitted by law. Liability for incidental or
.004 - .006 in (,10 - ,15 mm)
consequential damages are excluded to the extent exclusion is permitted by law. Some
.005 - .007 in (,15 - ,20 mm)
states or countries do not allow limitations on how long an implied warranty lasts,
and some states or countries do not allow the exclusion or limitation of incidental or
consequential damages, so the above limitation and exclusion may not apply to you.
This warranty gives you specific legal rights and you may also have other rights which
12.387 ci (203 cc)
vary from state to state and country to country
2.677 in (68 mm)
2.204 in (56 mm)
Vanguard®; Commercial Series
18 - 20 oz (,54 - ,59 L)
Consumer Use - 36 months
80W-90
Commercial Use - 36 months
4 oz (,12 L)
XR Series
10W30
Consumer Use - 24 months
10 oz (,30 L)
Commercial Use - 24 months
.030 in (,76 mm)
All Other Engines Featuring Dura-Bore™ Cast Iron Sleeve
180 lb-in (20 Nm)
Consumer Use - 24 months
.010 - .013 in (,25 - ,35 mm)
Commercial Use - 12 months
.004 - .006 in (,10 - ,15 mm)
All Other Engines
.005 - .007 in (,15 - ,20 mm)
Consumer Use - 24 months
Commercial Use - 3 months
Part Number
84002309
596760
596760
596760
597383
19576, 5402
19368
The warranty period begins on the original date of purchase by the first retail or
commercial consumer. "Consumer use" means personal residential household use by a
retail consumer. "Commercial use" means all other uses, including use for commercial,
income producing or rental purposes. Once an engine has experienced commercial
use, it shall thereafter be considered as a commercial use engine for purposes of this
warranty.
Standard Warranty Terms
3
1
These are our standard warranty terms, but occasionally there may
be additional warranty coverage that was not determined at time of
publication. For a listing of current warranty terms for your engine, go to
BRIGGSandSTRATTON.com or contact your Briggs & Stratton Authorized Service
Dealer.
2
There is no warranty for engines on equipment used for prime power in place
of a utility; standby generators used for commercial purposes, utility vehicles
exceeding 25 MPH, or engines used in competitive racing or on commercial or
rental tracks.
3
Vanguard installed on standby generators: 24 months consumer use, no
warranty commercial use. Commercial Series with manufacturing date before July
2017: 24 months consumer use, 24 months commercial use.
4
In Australia - Our goods come with guarantees that cannot be excluded under
the Australian Consumer Law. You are entitled to a replacement or refund for a
major failure and for compensation for any other reasonably foreseeable loss or
damage. You are also entitled to have the goods repaired or replaced if the goods
fail to be of acceptable quality and the failure does not amount to a major failure.
For warranty service, find the nearest Authorized Service Dealer in our dealer
locator map at BRIGGSandSTRATTON.COM, or by calling 1300 274 447, or by
emailing or writing to salesenquiries@briggsandstratton.com.au, Briggs & Stratton
Australia Pty Ltd, 1 Moorebank Avenue, Moorebank, NSW , Australia, 2170.
4
.
1, 2, 3
13