Burner And Orifice; Leak Testing - Disposable Lp Gas Cylinders; How To Check For Leaks; Fixing A Fuel Leak - Coleman 9406 Serie Manuel D'assemblage, D'entretien Et D'utilisation

Tighten by hand only. DO NOT use tools.
1. Before attaching propane
cylinder make sure both
control knobs are closed.
(Fig. 20)
2. Remove plastic cap from
top of propane cylinder
and screw cylinder into
regulator hand tight.
(Fig. 21)
3. To open lid, release the
cover latch and lift up.
(Fig. 22)
Burner and Orifi ce
1. Proper location of the burner with respect to the orifice is
important. To verify the proper installation of the burner
tube, use a screwdriver to remove the control panel. The
burner tube must be located over the orifice fitting. See Fig.
23 (control panel not shown).
Orifice Fitting
2. Check and clean the burner/venturi tubes for insects and
insect nests. A clogged tube can lead to a fire beneath the
appliance.
CAUTION
Burner Tube
Burner

Leak Testing - Disposable LP Gas Cylinders

To Prevent Fire or Explosion Hazard:
• NO SMOKING. DO NOT use or permit sources of ignition in
the area while doing a leak test.
• Perform leak tests outdoors only.
• NEVER perform a leak test with fire or flame.

How to Check for Leaks

Fig. 20
1. Make a soapy solution of equal parts mild liquid
dishwashing detergent and water.
2. Turn off the burner control knobs.
3. Apply a soap solution to the connections indicated with the
arrows. (Fig. 24) If bubbles appear at these areas, a leak is
indicated.
Fig. 21
No Smoking
Fig. 22
No Flame

Fixing A Fuel Leak

If you detect a leak:
1. Stop a leak by tightening the loose joint, or by replacing
the faulty part with a replacement part recommended by
Coleman. DO NOT attempt to repair the cylinder if it should
become damaged; the cylinder MUST be replaced.
2. If you are unable to stop a leak, remove the cylinder from the
grill. DO NOT use the grill until the leak is corrected.
When to test for leaks:
1. Perform a leak test each time the gas supply cylinder is
connected to the regulator. Leak test anytime a part of the
gas system is replaced.

Start-Up Check List

Fig. 23
Failure to follow these safety steps before using the grill each
time could result in a fi re that could be hazardous to you, your
appliance or property. It is especially important to observe
these steps after the grill has been stored, moved or cleaned.
English - 7
DANGER
WARNING
Fig. 24