General Maintenance And Lubrication Chart - Yamaha RS Venture RST90GTY 2009 Mode D'emploi

GENERAL MAINTENANCE AND LUBRICATION CHART

GENERAL MAINTENANCE AND LUBRICATION CHART
ITEM
Engine oil
* Engine oil filter cartridge
* Cooling system
Primary and secondary
*
clutches
* Drive chain
* Drive chain oil
* Brake and parking brake
Control cables
* Disc brake installation
* Slide runners
* Skis and ski runners
* Steering system
* Steering bearings
Skis and front shock absorb-
*
ers
* Suspension component
Fittings and fasteners
* Battery
TIP
Brake system:
• After disassembling the master cylinder or caliper cylinder, always change the brake fluid. Regularly check
the brake fluid level and add fluid if necessary.
• Replace the oil seals of the master cylinder and caliper cylinder every two years.
• Replace the brake hose every four years, or if cracked or damaged.
REMARKS
• Change (warm engine before draining)
• Replace.
• Check coolant level.
• Air bleed the cooling system if necessary.
• Check engagement and shift speed.
• Adjust if necessary.
• Inspect sheaves for wear and damage.
• Inspect weights/rollers and bushings for wear for primary.
• Inspect ramp shoes/bushings for wear for secondary.
• Replace if necessary.
• Lubricate with specified grease.
• Check chain slack.
• Adjust if necessary.
• Check oil level.
• Change.
• Adjust free play and/or replace pads if necessary.
• Change brake fluid.
• Make sure that operation is smooth.
• Lubricate if necessary.
• Check for slight free play.
• Lubricate shaft with specified grease as required.
• Check for wear and damage.
• Replace if necessary.
• Check for wear and damage.
• Replace if necessary.
• Check toe-out.
• Adjust if necessary.
• Check bearing assemblies for looseness.
• Lubricate with specified grease.
• Lubricate with specified grease.
• Lubricate with specified grease.
• Make sure that all nuts, bolts and screws are properly tightened.
• Tighten if necessary.
• Check condition.
• Charge if necessary.
3
INSP
ADJ
INITIAL EVERY
Seasonally
1 month
or
or 800 km
4000 km
(500 mi)
(2500 mi)
(40 hr)
(200 hr)
Every
20000 km
(12000 mi)
Whenever operating eleva-
tion is changed.
Initial at 500 km (300 mi) and
every 800 km (500 mi) there-
after.
See TIP following this chart.
Every 1600 km (1000 mi)
2