Maintenance - Clarke American Sanders C.A.V. Super 30 Manuel De L'utilisateur

ENGLISH
EN
OPERATING INSTRUCTIONS CONT.
Cleaning Dust Filter
NOTE: Because of the Cyclone design used on this
machine, large bag filters or multistage filtering systems
are not needed. This simple paper filter captures any dust
that does not drop out of the air due to the cyclone effect.
This filter is easy to remove, replace or clean on a regular
basis.
1. Remove filter housing toggle clamps (A) and open filter
door (B) to expose element (see figure 4).
2. Remove filter retaining plate and pull filter straight out to
remove from housing (see figure 5).
3. Gently "Rap" filter to dislodge any loose dust.
4. Re-install filter while being careful to seat it properly.
NOTE: Filter will require regular cleaning, at least daily.
NOTE: When the filter pressure gauge reads 22" W.C., the
vacuum should be shutdown and filter cleaned. It is
recommended that you keep 1-2 spare elements available
at all times.

MAINTENANCE

1. ENGINE: Refer to the attached service manual for
engine servicing.
2. BATTERY: The battery provided with your machine is of
the lead acid type. The battery cables should be
checked daily for corrosion and tightness.
3. BLOWER: During the normal use of your machine, no
maintenance is required on the blower. NOTE: Do not
replace the original blower with any other blower other
than the factory approved replacement.
4. DRIVE BELT: The drive belt should be checked daily for
proper tension, alignment and wear.
5. FILTER: The vacuum filter should be checked daily or
more often for build up and damage.
6. PLASTIC COLLECTOR BAG: The plastic trash bag
should be empty at start of operation and should be
disposed of properly at end of operation. NOTE: See
"Start Up", figures 2 and 3, for proper installation of
plastic trash bag.
If a problem, noise or vibration should occur, stop the
equipment immediately!! Contact the factory as soon as
possible. Do not operate this equipment until it has been
thoroughly checked by the factory.
-8- Clarke ® American Sanders
B
Figure 4
Figure 5
Operator's Manual (EN) - C.A.V. Super 30
A