Health And Safety; Pre-Start Safety Checks - Belle Altrad PCX 350 Manuel De L'opérateur

Health and Safety

Vibration
Some vibration from the compaction operation is transmitted through the handle to the
operator's hands. The Belle Group Plate Compactor range has been speci¿ cally designed to reduce hand/arm vibration levels. Refer
to speci¿ cations & technical data for vibration levels and usage times (recommended maximum daily exposure time). DO NOT exceed
the maximum usage times.
PPE (Personal Protective Equipment).
Suitable PPE must be worn when using this equipment i.e. Safety Goggles, Gloves, Ear Defenders, Dust Mask and Steel Toe capped
footwear. Wear clothing suitable for the work you are doing. Tie back long hair and remove any
jewellery which may catch in the equipment's moving parts.
Dust.
The compacting process will occasionally produce dust, which may be hazardous to your health. Always wear a mask that is suited to
the type of dust being produced.
Fuel.
Do not ingest fuel or inhale fuel vapours and avoid contact with your skin. Wash fuel splashes immediately.
If you get fuel in your eyes, irrigate with copious amounts of water and seek medical attention as soon as possible.
Exhaust Fumes
CAUTION
The exhaust fumes produced by this equipment are highly toxic and can kill!
Do not operate the compactor indoors or in a con¿ ned space, make sure the work area is adequately ventilated.
Pre-Start Checks
Pre start-up inspection
The following Pre-start-up inspection must be performed before the start of each work session or after every four hours of use,
whichever is ¿ rst. Please refer to the service section for detailed guidance. If any fault is discovered, the compactor must not be used
until the fault is recti¿ ed.
1. Thoroughly inspect the compactor for signs of damage. Check componenents are present and secure. Pay special attention
to the belt drive safety guard ¿ tted between the engine and the vibrator unit.
2. Check the engine oil level and top up as necessary.
3. Check the engine fuel level and top up as necessary.
4. Check for fuel and oil leaks.
23